The fact is that, at least for today, the rule for NASCAR racing is no traction co
In the foreground is a Davis Technologies ETC mated by an enterprising soul to a six-pin
One of the electronic countermeasures against ETC used by NASCAR is this $1,800 Micropho
The purposely-blurred circuit board shows just how small the current ETC digital electroni
This is a used ETC system using radar (black cylinder at left) to measure ground speed to
For more than a year, NASCAR and other U.S. racing sanctioning bodies tech inspectors have been:
1. Randomly cutting into ignition control boxes confirming the internals are legit;
2. Extracting car wiring harnesses and checking each wires origin and destination;
3. Disassembling tachometers, looking for extra electronics inside;
4. Applying engine seals to wiring connectors to detect if theyve been unplugged;
5. Using high-frequency sound detection equipment to monitor engine sounds on track; and
6. Enacting post-race claiming of ignition controls from racers.
These are just some of the countermeasures inspectors have employed in their quest to control the spread of Electronic Traction Control (ETC), and theyre about to be stepped up.
We might soon see wiring harness routing and mounting regulated where all of it (about 30 feet total in a typical Cup car) has to be out in the open for inspection along with the ignition controls; say placing them on top of the dash. You can assume the wiring harness will not be within reach of the driver, either.
In a highly unusual move for such a close-to-the-vest organization, NASCAR has gone public about its search and reveal mission for clandestine traction enhancing electronics. The very public grumbling from some major NASCAR competitors and team owners in its top three divisions, which alluded to ETC aiding and abetting some racers performance, needed some tempering, or at the least major spin-doctoring. The credibility of the organization was being called into question. It prides itself on being a series of drivers, not microprocessors, and they are not about to allow microprocessor regulation of engine power to assist traction.
The first spin-control salvo was at the Martinsville spring Winston Cup race in 2002, where majordomo Mike Helton placed racers on alert in their drivers meeting by brandishing a couple of ETC devices NASCAR had procured. He made it clear his inspection force was on the prowl and the penalties would be appropriately high for anyone caught with it.
Then, at the Pepsi 400, all the top NASCAR brass, from Bill France Jr. on down, attended an innocent sounding Competition Update press conference before the race. It was to inform the media that NASCAR was on top of this perceived ETC problem, and to indicate it was going to step up its rules and inspection measures.
Head Winston Cup inspector John Darby reiterated the penalty for getting caught with ETC would likely be the most severe ever in NASCAR. The threat of making the record book as the team/sponsor receiving the largest fine or suspension or points penalty in NASCAR history is the prime deterrent NASCAR has.
Nevertheless, you can take to the bank that NASCAR wouldnt expend all this inspection and public relations effort to catch an electronic boogeyman if it werent in use.
ETC Is Nationwide
Clandestine ETC use is not confined to the upper reaches of U.S. touring series; it is pervasive in U.S. racing even to the grassroots level. In my researching and writing about ETC over the past two years, sources racing in Winston Cup, Busch Grand National, DIRT Modifieds, Silver Crown, dirt Late Models, big-block pavement Late Models, IMCA-type Modifieds, and other racing series have acknowledged the use of ETC. The technology is even making its tentative way into boat racing, where engine power is being modulated based on rpm jitter.
The basic physics and tactics of the microprocessor management of tire slip are well developed. Many high-performance passenger cars have ETC, and the cost of miniaturization and packaging of electronic sensing and microprocessor controlling components has become impressively affordable. So affordable that an electronic specialist can buy off-the-shelf components and build ETCwhether for sale on the open market, or for use in-house for a race team.
Effective mass-produced ETC units for racing are available today that are so small and portable they are almost undetectable. Costing in the $6,500 range, they are expensive for many amateur racers, but pocket change for professional efforts. You are paying a premium for the stealth technology, given its widespread illegality. The September 1999 issue of our sister magazine, Circle Track , examined the TracMate electronic traction control system, which was/is representative of a typical sensor-based unit. This system was effective, but not exactly undetectable because of its bulk and accompanying sensor wiring.
Today, Davis Technologies is one manufacturer of ETC that is sensor-less and not much bigger than a 9-volt battery. According to Shannon Davis, the units designer, power is sourced from the original +9 volt battery and the ignition timing is adjusted through the battery case to chassis ground. That is, this portable unit detects wheel slip by monitoring an engine rpm (tach) signal, and retarding ignition timing to soften the engine power. Damped engine power reduces torque to the driving wheels and therefore can assist traction by keeping them from being overpowered.
This ETC unit does not have to be permanently hard-wired into the cars harness. Thus, tech inspectors can cut away on ignition controls, claim or swap them out, or apply engine seals to standard wiring connector junctions till their hearts are content theyre policing ETC. But they will be hard-pressed to detect this portable unit that is separate from the ignition controls internal circuitry and can be temporarily wired into the cars wiring harness. Thats why NASCAR is likely to make its race cars ignition wiring harness be completely exposed, making connecting any auxiliary microprocessor electronics and wiring hard to do without detection.
Does ETC Work?
Understandably, getting any performance numbers out of racers about ETC is not something they randomly bandy about. One Winston Cup racer acknowledged, At Greenville-Pickens (South Carolina) its worth 0.3 second a lap. ETC can improve fuel mileage in a carbureted race engine because throttle transitions are electronically damped and less fuel is expended. Tire wear/conservation can be improved because it can calm down all the little tire slips that are going on during racing that wear and heat the tiresthe electronics can react faster than a human can in both cases.
Mark Richards, owner of Rocket Chassis, one of the top chassis manufacturers in Late Model racing, sells the Davis Technologies ETC. He doesnt make a big deal about it, but he knew he was competing against it on tracks across the country. So he began investigating ETC last year to find out if there was any real value to the claims he was hearing. He disclosed some hard test numbers about ETC.
Were offering everything for a customer to win, he notes. It wont make a 15th- or 10th-place car win a race, and it wont help the lap times of the best racers out there. But the average driver can pick up to 0.1-0.2 second. Weve tested it (the Davis Technologies units). If (Late Model racer) Dale McDowell runs a 16.50 second lap without it, I run a 16.70-80 second lap without it in the same car on the same track. But I can hit the 16.50-60s if I use it on an open track.
Richards clarifies, If Dale uses it, he can become more consistent and achieve more 16.50s over a number of laps. Basically, ETC helps a good racer stay good. Richards also says that traction control, has become the number one excuse in racing: I got beat, I think the winner had traction control is all too common a post-race refrain these days. He states a reasonable legitimizing counter-argument. Racers still have to have the skills to race: drive in traffic; adapt to changing track conditions; and adapt to the cars changing performance, he concludes.
Time Better Spent
NASCAR and major touring series may choose to continue to police ETC, and will likely restrict its use, but its unlikely to be totally eradicated. They might take a page from Formula 1 or CARTs rule book and legalize ETCthose sanctioning bodies recognized the futility of trying to police it versus the formidable technical resources of their racing teams. Then, they could apply their resources to bigger problems.
ETC is just one of the many pieces of creative engineering going on in racing, and its become one of the most difficult to detect. Legalize it and the price could come down to the $500 to $1,000 range, and then expend the tech inspection efforts on finding ways to improve driver safety, for instance. That has more return on investment in the long run for racings future.